Properties of Isotactic Polypropylene Irradiated in Various Atmospheres
Чланак у часопису
МетаподациПриказ свих података о документу
In this paper, changes in structure and physical properties of stabilized isotactic polypropylene (iPP) were created by gamma irradiation, up to a dose of 700 kGy, in different media: air, deionized distilled (DD) water and acetylene. Two main effects occur when polyolefins, such as iPP, are subjected to ionizing radiation: crosslinking and scission of macromolecules. The domination of one or the other of these competitive processes is determined by both the structural peculiarities of the polymers and the experimental irradiation conditions. Gel and infrared (IR) spectroscopy measurements were used to determine the changes in the degree of network formation and oxidative degradation, respectively. Sol gel analysis was studied in detail using the Charlesby-Pinner (C-P) equation. The radiation-induced changes in the structure and evolution of oxygen-containing species were also studied through dielectric loss (tan delta) analysis in a wide temperature and/or frequency range. Evolution o...f low temperature dielectric relaxations with gamma irradiation was investigated. The results showed that degradation was the major reaction in the initial step of irradiation, no matter what the atmosphere was. The C-P equation seemed applicable when stabilized iPP was irradiated within a certain dose range in various atmospheres. The iPP irradiated in acetylene/air had the lowest/highest values for oxidation level, dielectric losses, D(g) and G(s)/G(x) values. The calculated D(g) values are 1.5 and 5 times larger for the irradiation in DD water and air than for the acetylene. Furthermore, our data confirm that oxidation strongly affects the gel point but has a much lower effect on the G(s)/G(x) ratio. In the case of dielectric relaxation measurements, the connection between the oxidative degradation and dielectric properties is well established and is in good agreement with IR spectroscopy measurements. The amount of carbonyl, hydroperoxide and other polar groups is much higher for the irradiation in air than in other media, leading to higher dielectric losses. Disappearance of low temperature (delta and gamma) relaxations with gamma radiation confirmed great sensitivity of iPP structure to radiation-induced changes. Complete vanishing of the gamma relaxation in iPP samples irradiated in air is connected with a large radiation-induced oxidative degradation in this medium. Similar crosslinking, oxidation and dielectric behaviour was observed for the samples irradiated in water and acetylene, indicating DD water as a good crosslinking medium.
Кључне речи:Gamma irradiation / Polypropylene / Crosslinking / Oxidative degradation / Dielectric properties
Извор:Hemijska industrija, 2010, 64, 3, 201-208
ISSN: 0367-598X (print)